Sony D117CD Car Stereo Manual

The Sony D117CD is an in-dash CD receiver designed for car audio systems, featuring AM/FM radio with tuner presets, CD playback, auxiliary input, and basic audio controls. It offers a detachable faceplate for security, adjustable bass and treble, loudness compensation, and compatibility with various vehicle wiring harnesses. Below are key sections for safety, features, installation, setup, operation, and troubleshooting.

1. Features at a Glance 2. Installation 3. First-Time Setup 4. Specifications 5. Controls and Settings 6. Connecting Devices 7. Playing CD Media 8. Security Features 9. Care & Cleaning 10. Regulatory Information 11. Troubleshooting

Features at a Glance

Key components: In-dash CD receiver, Detachable Faceplate, Remote Control (if included), Wiring Harness, Antenna Connector, Auxiliary Input.

Feature	Description
AM/FM Tuner	With 18 FM and 6 AM presets for station memory
CD Player	Plays standard audio CDs and CD-R/RW discs
Auxiliary Input	3.5mm jack for connecting external audio devices
Detachable Faceplate	Security feature to deter theft
Audio Controls	Bass, Treble, Balance, Fader, Loudness
Power Output	Typically 50W x 4 channels (max)
Illumination	Adjustable display color to match dashboard lighting
Clock	Built-in digital clock with time display
Power Antenna Control	Wire to activate power antenna when unit is on
Remote Control Sensor	For optional remote control operation

Installation

Unpack and inspect contents. Ensure vehicle battery is disconnected before beginning.

Remove existing stereo: Use removal tools to extract old unit from dashboard.
Connect wiring harness: Match colors of the Sony harness to your vehicle's harness (red=ignition, yellow=battery, black=ground).
Connect antenna: Plug vehicle antenna cable into the rear antenna port.
Mount the unit: Slide the D117CD into the dashboard opening and secure with mounting sleeve.
Reconnect battery and test: Ensure all connections are secure before powering on.

WARNING! Disconnect vehicle battery to prevent short circuits. Ensure all wires are properly insulated.

First-Time Setup

Power on the unit; follow basic configuration steps.

Set the clock: Press and hold the CLOCK button, then use TUNE/SEEK to adjust time.
Program radio presets: Tune to desired station, press and hold a preset button (1-6) to store.
Adjust audio settings: Use BASS, TREBLE, BALANCE, and FADER to suit your listening preference.
Set display illumination: Use the DIMMER or COLOR button to match vehicle interior lighting.

CAUTION! Perform setup only when vehicle is parked in a safe location.

Specifications

Power Supply: 12V DC, negative ground.
Output Power: 50W x 4 (Max), 17W x 4 (RMS).
CD Compatibility: Audio CD, CD-R, CD-RW.
Tuner Sensitivity: FM: 10.3 dBf, AM: 30 µV.
Audio Controls: Bass (±10 dB), Treble (±10 dB), Balance/Fader, Loudness On/Off.
Preamp Outputs: May include front/rear/subwoofer RCA outputs (model dependent).
Auxiliary Input: 3.5mm stereo mini-jack.
Dimensions: Standard DIN size (approx. 7" x 2").
Operating Temperature: 14°F to 158°F (-10°C to 70°C).

Controls and Settings

Access functions via front panel buttons or optional remote control. Front Panel: POWER/VOLUME knob, SOURCE, BAND, TUNE/SEEK, PRESET buttons, OPEN/CLOSE for CD, AUX button.

Remote (if included): POWER, VOLUME, SOURCE, PRESET, TUNE, PLAY/PAUSE, etc.

Audio Settings: Adjust BASS, TREBLE, BALANCE (left/right), FADER (front/rear), LOUDNESS (boost at low volumes). Radio: Store up to 18 FM and 6 AM presets; use manual or seek tuning. Display: Adjust brightness/color via DIMMER or COLOR button. Clock: Set time display format (12/24 hour).

Connecting Devices

Antenna: Standard motor vehicle antenna plug. Auxiliary: 3.5mm cable from portable player to AUX IN jack. External Amplifiers: Use RCA preamp outputs if available.

Ensure unit is off before connecting devices.
Plug auxiliary cable into the 3.5mm AUX IN jack on the front or side panel.
Select AUX mode by pressing the SOURCE button until "AUX" appears on display.

Tip: Use a high-quality shielded cable for auxiliary connection to minimize noise.

Playing CD Media

Supports standard audio CDs, CD-R, and CD-RW discs.

Insert disc: Press OPEN/CLOSE, load CD with label side up.
Play: Press PLAY; disc will start automatically. Use TUNE/SEEK to skip tracks.
Pause: Press PLAY/PAUSE to temporarily halt playback.
Stop/Eject: Press STOP; press OPEN/CLOSE again to eject disc.
Repeat/Shuffle: Press RPT or SHUF button during playback for repeat or random play modes.
Scan: Press and hold TUNE/SEEK to quickly sample each track.
Disc Information: Press DISP or TEXT to show track title/time (if supported by disc).

WARNING! Do not use damaged or irregularly shaped CDs. Avoid extreme temperatures.

Security Features

Detachable Faceplate: Remove by pressing release button and sliding faceplate off. Store separately when leaving vehicle. Security Code: Some models may require a PIN code upon reconnection to prevent unauthorized use.

Care & Cleaning

Disconnect power before cleaning. Use soft, dry cloth for faceplate and display. For stubborn dirt, use cloth slightly dampened with water. Do not use solvents.

CAUTION! Never spray cleaning fluids directly onto the unit. Keep CDs clean and free of scratches.

Regulatory Information

FCC Part 15: Class B digital device; complies with limits for vehicle use. This device may not cause harmful interference. Copyright © Sony Corporation. For support, visit www.sony.com/electronics/support or contact Sony customer service at 1-800-222-7669.

Troubleshooting

Symptom	Possible Cause	Corrective Action
No power	Blown fuse, wiring	Check vehicle fuse box and in-line fuse; verify wiring connections (yellow, red, black).
No sound from speakers	Speaker wires, settings	Check speaker connections; ensure balance/fader not set to extreme; verify speaker impedance.
Radio poor reception	Antenna connection	Ensure antenna cable is fully inserted; check antenna for damage.
CD won't play	Disc, lens dirty	Use only compatible CDs; clean disc; if problem persists, lens may need professional cleaning.
Unit asks for code	Security feature	Enter the 4-digit security code (found in owner's card). If lost, contact Sony support.
Auxiliary input not working	Connection, source	Ensure cable is fully plugged in; check volume on external device; select AUX mode on stereo.

Reset: Disconnect power for 5 minutes to reset microprocessor.

Service: 1-800-222-7669; www.sony.com/electronics/support